Circuit inside LED tube

Chipshow’s LED tube page gives some views what LED tubes look like.

T515_LED_tubes

As you can see there are many LEDs inside a LED tube. The most economical way to run sich LEDs from mains power is to connect many LEDs in series and then use some current limiting circuit to set the drive current right for those LEDs. One LED tube can contain one or more such sets of series connected LEDs.

LED Light Tube Circuit Diagram gives a quite simple looking circuit diagram for a 230V mains powered LED tube:

ledtube1

The circuit looks pretty simple. The downside of this kind of design is the power loss by the current limiting resistor and the fact that the light output flickers at 100 Hz frequency. I would also expect a poor regulation on mains voltage variations (if mains voltage changes the light output changes quite much). I have not tried this particular design, but those are normal problems on this kind of simple LED circuits.

LED TUBE LIGHT (AC) article tells how to make a LED Tube Light. This kind of tube light is a row of LED’s which runs on 110 or 220 volts AC, just like your ordinary Fluorescent Tube Light. The following circuit diagram is for 110V operation (article has instruction for modifications for 220V operation).

ledtube_STEP-1

This circuit diagram use a capacitor+resistor for current limiting and uses just 30 LEDs in series. Maybe a little bit better (lower losses) than resistor only solution.

The ideal solution for driving those LEDs would be a suitable constant current type power source. This could be for example built with a mains power rectifier + filtering capacitor followed by a low loss constant current source (switch mode power supply wired to constant current mode).

LED short-circuit such a situation-led tube article tells some information how to detect damaged LEDs on the LED tube circuit before they cause more serious problems. The above circuits do not have any such protection, so damaged short circuited LED (or more than one) can cause danger of circuit overload (overheating of resistor, too much current to other LEDs etc.). At least potential dangers.

National Semiconductor Newsletter: Multiple LED Strings. One LED Driver (e-mailed to me) says:
When lighting designers arrange a series of LED strings in applications such as street lights or industrial lights (and this applies to LED tubes built in the same way), each string needs to be driven at a consistent current by an individual LED driver. However, the output voltage often varies due to differences in the manufacturing of the LEDs. To compensate, LED drivers provide higher-than-needed voltage to ensure proper operation of each LED string. Too much voltage, though, can waste power.

National Semiconductor newsletter says that their LED drivers with Dynamic Headroom Control (DHC), such as LM3464, monitor the output voltage of the LED strings and dynamically adjust the voltage to get the highest efficiency on the output. LM3464 drives four strings of up to 80V per channel for LED-intensive applications such as industrial, outdoor area, and automotive lighting.

And for bonus those that work on lowe voltage lights: LED Ideas web page gives a design for LED tube lamp that runs on 12V DC power. There are good pictures on the mechanical construction of the circuit inside tube and even how to built those fluorescent tube bi pin contacts ourself.

83 Comments

  1. S.V.dhapare says:

    What are the advantages of led tube light over flowrecent tube lights.

    Are the led tubelights good for reading?

    What is the lux value of led tubelight comparing with flowrecent tube light?

    Reply
    • tomi says:

      The LUX values depend on the product you choose. Depending on your selection LED tube can output more, same amount or less light than the original fluorescent lamp.

      Reply
  2. S.V.dhapare says:

    What are the advantages of led tube light over flowrecent tube lights.

    Reply
  3. Thyromine Erfahrungen says:

    Remarkable issues here. I am very glad to see your post.
    Thank you a lot and I am having a look forward to
    touch you. Will you kindly drop me a mail?

    Reply
  4. Amalia Junkersfeld says:

    I have noticed that of all kinds of insurance, health care insurance is the most marked by controversy because of the conflict between the insurance plan company’s obligation to remain adrift and the customer’s need to have insurance. Insurance companies’ commission rates on wellness plans are incredibly low, therefore some providers struggle to gain profits. Thanks for the suggestions you write about through this site.

    Reply
  5. Shane Wendy says:

    I do consider all of the ideas you’ve presented to your post. They are very convincing and will definitely work. Still, the posts are very brief for novices. May you please extend them a bit from subsequent time? Thank you for the post.

    Reply
  6. Provillus Nz says:

    Thank you a bunch for sharing this with all people you actually
    recognise what you are talking approximately! Bookmarked.
    Please additionally seek advice from my site =).
    We will have a link exchange agreement between us

    Reply
  7. Lighcore Lighting says:

    This website contains nice information for LED Manufacturing.we are brisbane based high quality LED lighting supplier.please have a look on our website.

    http://www.lighcorelighting.com.au/

    Thanks

    Reply
  8. driving school says:

    Hi colleagues, fastidious piece of writing and nice arguments commented at this
    place, I am actually enjoying by these.

    Reply
  9. LED Dimmable says:

    I’ve been surfing on-line greater than 3 hours as of late, but I never found any interesting article like yours. It is beautiful price sufficient for me. Personally, if all site owners and bloggers made just right content as you probably did, the internet will be a lot more useful than ever before.

    Reply
  10. LED floodlight says:

    My brother recommended I might like this web site. He was once entirely right. This put up actually made my day. You cann’t believe simply how so much time I had spent for this info! Thanks!

    Reply
  11. Thyromine.Com.Au says:

    Hello, i think that i saw you visited my site so i came to “return the favor”.I’m trying to find things to
    improve my website!I suppose its ok to use some of your ideas!!

    Reply
  12. Thyromine Success Stories says:

    Good post. I learn something totally new and challenging on sites I stumbleupon every day.

    It will always be useful to read through articles from
    other authors and use something from other websites.

    Reply
  13. Shiharan says:

    Hi, i recommend adding an electrolytic filter capacitor to the circuit along with a bridge rectifier to reduce flickering.

    -Shiharan

    Reply
  14. Carmine Salkeld says:

    merry Christmas i made a blog with wonderful photos of dogs

    Reply
  15. Joe Belzer says:

    I do not understand the way LEDS are wired—

    Is the top row connected positive to positive and the positive from bottom row connected to top row

    Bottom row negative to negative and negatives from top row connected to bottom row.

    Took a led and connected positive to positive—negative to negative –got light–

    reversed polarity and got no light—NOT an Electrical engineer OBVIOUSLY—-

    Spent lots of time looking for explanation—-PLEASE EXPLAIN your circuit

    Thanks

    Reply
  16. Joe Belzer says:

    Yes–the upper is going left and the bottom is going right—-

    Please clarify–

    Thank You

    Reply
  17. Savin says:

    LED tube is highly recommended LED equipment. I already using this LED Tubes, its really such a great tube to save power energy.

    Reply
  18. bharathi says:

    i wil try this experiment in 230v ac,22k400v c,1/2 k,1w resister.at first the bulb will glow then the resister will burned.what can i do the next step.plz tell me.

    Reply
  19. Shalanda says:

    It’s difficult to find well-informed people about this
    topic, however, youu seem like you know what you’re talking about!
    Thanks

    Reply
  20. vioxx says:

    My brother suggested I might like this web site. He was totally right.
    This post truly made my day. You can not imagine simply
    how much time I had spent for this information! Thanks!

    Reply
  21. merry christmas pictures 2014 says:

    I’ve bee exploring for a little bit for anny high quality articles or weblog posts on this kind of arfea
    . Eploring inn Yahoo I finally stumbled upon this site.

    Studying this information So i’m glad to convey that I hazve an incredibly good uncanny feeling I discovered exactly
    what I needed. I so much indisputsbly will make sure tto do not overlook this web site and provides it a look regularly.

    Reply
  22. TOMOMORI CO., LTD says:

    Dear Customer
    Hello
    Classic type LED FLOOD LIGHT
    We specialize in the production of various models of LED floodlight types,
    Our products have passed CE, ROHS certification, mainly exported to European countries
    Our monthly production volume is: 10 million units
    1000units -5000units order quantity, delivery time: 3-5 days
    Epistar 35mil – Warranty time: 2 years
    http://www.grade-floodlight.com/Classic-Led-Flood-Light.html
    Classic type LED FLOOD LIGHT 10W 2.8USD/pcs
    Classic type LED FLOOD LIGHT 20W 6.2USD/pcs
    Classic type LED FLOOD LIGHT 30W 9.5USD/pcs
    Classic type LED FLOOD LIGHT 50W 14.7USD/pcs
    Classic type LED FLOOD LIGHT 70W 20.0USD/pcs
    Classic type LED FLOOD LIGHT 80W 24USD/pcs
    Classic type LED FLOOD LIGHT 100W 30USD/pcs
    Classic type LED FLOOD LIGHT 120W 45USD/pcs
    Classic type LED FLOOD LIGHT 150W 55USD/pcs
    Classic type LED FLOOD LIGHT 200W 65USD/pcs
    Classic type LED FLOOD LIGHT 250W 75.0USD/pcs
    Classic type LED FLOOD LIGHT 300W 125.0USD/pcs
    Please visit our website at: http://www.grade-floodlight.com
    Welcome to your order
    Our service time: 24 hours x6
    Best regards
    TOMOMORI CO., LTD
    Address : 13F/B3 Floor , second industrial zone,
    Dayangtian ,Fuyong Street, Bao’an DIstrict,
    Shenzhen China
    http://www.grade-floodlight.com
    Tel : +86-755-33662366
    Fax : +86-755-33662522
    Skype:ZHANG.KING6
    E-mail : [email protected]
    E-mail : [email protected]

    Reply
  23. Tomi Engdahl says:

    Led light tubes are the first and so far the only LED lamps format, which has received international harmonized standard. IEC approved E N 62776 – the standard for many years after twisting in mid-December 2014.

    Standardization allows for traditional T8 fluorescent tubes are compatible with LED light tubes. In addition, the standard defines the characteristics of LED light tube, so that they are compatible with each other.

    The new standard of the old fluorescent lighting tubes can be exchanged with one of led light tube. The standard also defines the characteristics required of a light pipe, such as mechanical strength, physical dimensions and electrical characteristics. It also describes the products of the required marks and uniform testing practices.

    Source: http://www.etn.fi/index.php?option=com_content&view=article&id=2311:ledivaloputki-sai-oman-standardin&catid=13&Itemid=101

    Reply
  24. Tomi Engdahl says:

    Two different versions of LED lamps in linear tubes can be found in the market: retrofit and
    conversion.

    Retrofit LED lamps are lamps which can be inserted in an existing luminaire without modification. This operation has the character of maintenance.

    A conversion LED unit is a lamp which requires changes in the luminaire components. In
    this case safety requirements have to be checked in a different way taking into consideration thermal and electrical behaviour of the new components, and the possibility that the user will insert again a tubular fluorescent lamp.

    Source: https://shop.austrian-standards.at/Preview.action;jsessionid=28B9467B0F5F9EBC3559A6D91E8F055E?preview=&dokkey=470272&selectedLocale=en

    Reply
  25. Brett Cravaliat says:

    I’m now not positive where you’re getting your information, but good topic.
    I needs to spend a wnile finding out more or understanding more.

    Thak you for grwat information I was on the ookout for this info for my mission.

    Reply
  26. shelley says:

    Dear Sir/madam,

    Hope everything goes well and have a nice day!

    We have obtained your company and your product of LED T8 tube light from your website, and we are writing to enquire whether you would be willing to establish business relations with us.

    There are some advantages of our LED T8 tube light:
    –Led type: SMD 2835
    –Input voltage: AC85-277V
    –Lifetime: more than 50000 hours
    –CRI: >80
    –PF: >0.95
    –luminous Efficiency: >100 lm/w
    –CCT: WW: 2500-2800k, 2800-3200K; NW:3750-4250K; PW: 4750-5300k,5700-6500K
    –Beam angle: 120
    –Warranty: 3 years
    –Certifications: CE/ROHS/UL/SAA/TUV
    –power type: isolated
    –Cap: 350 rotatable

    Established in 2010, Shen Yao Opto-electronic (Shenzhen) is a professional manufacturer specializing in LED lighting applications, LED lighting product development, production and sales.our main products are LED strips, LED tubes, LED panel lights, LED bulbs, etc.

    We will be happy to give you a quotation upon receipt of your detailed requirements.

    We looking forward to hearing from you soon.

    Best Regards

    shelley

    Reply
  27. Tomi Engdahl says:

    LED products billed as eco-friendly contain toxic metals, study finds
    https://www.sciencedaily.com/releases/2011/02/110210124136.htm

    Reply

Leave a Comment

Your email address will not be published. Required fields are marked *

*

*